Photocatalytic Removal of Methylbenzene Vapors by MnO2/Al2O3/Fe2O3 Nano composite

Maryam Feiz-Arefi, Farshid Ghorbani-Shahna, Abdulrahman Bahrami, Hossein Ebrahimi, Alireza Mahjub

Abstract


Methyl benzene, which has carcinogenic effects, is a volatile organic compound that is widely used in various industries. Nano composites of Mno2/Al203/Fe203, which is a new photocatalyst, have not been applied to remove contaminants from air streams. Therefore, the aim of the present study was to investigate the photocatalytic removal of ethyl benzene by using this nano composite activated by visible light. Morphological characteristics of the synthesized Nano composite in a sol-gel method are determined through XRD, FTIR, and SEM. Through the photocatalyst process and by the use of visible light radiation, the synthesized Nano composite is used to degrade ethyl benzene in the gas phase. In order to estimate the main effects and interaction ones and to optimize the experiment numbers, the response surface method was used. Operational parameters investigated in the study are the initial concentration of contaminants, relative humidity, and the residence time, which were considered in three levels; further, the experiments were designed by Design Expert version 9 software. The results show the Nano composite particle sizes were less than 82 nanometers. The findings also indicate that relative humidity and residence time were effective parameters in removal efficiency of ethyl benzene. This Nano composite, at the optimal conditions, was capable of removing 98.72% of the pollutants, with an initial content of 300 ppm. MnO2/Al2O3/Fe2O3 Nano composite is a suitable catalyst to remove ethyl benzene from air streams. Among the features of the Nano composite are reaction at room temperature and lower production dangerous byproducts, which are the main advantages of this Nano composite as compared with other nano composites.

Keywords


Nano-Composite, Ethyl benzene, Photocatalyst, MnO2/Al2O3/Fe2O3

Full Text:

XML PDF

References


Nath R.K, Zain M, and Jamil M. An environment-friendly solution for indoor air purification by using renewable photocatalysts in concrete:A review. Renew Sust Energ Rev. 2016; 62(9):1184-94.

Ojala P.S., Laitinen T, Koivikko NN, Brahmi R, Gaálová J, et al. ,Catalysis in VOC abatement. Top Catal. 2011;54(11):16-18.

Dhada I, Nagar P, Sharma M. Photo-catalytic oxidation of individual and mixture of benzene, toluene and p-xylene. Inte J Env Sci Tech. 2016; 13(1):39-46.

Hinojosa-Reyes M, Arriaga S, Diaz-Torres L, Rodríguez-González V. Gas-phase photocatalytic decomposition of ethylbenzene over perlite granules coated with indium doped TiO 2. Chem Eng J.2013;224(5):106-13

Rohollah Maghsoodi Moghadam, Abdulrahman Bahrami, Farshid Ghorbani, Hossein Mahjub, Dariush Malaki. Investigation of Qualitative and Quantitative of Volatile Organic Compounds of Ambient Air in the Mahshahr Petrochemical Complex In 2009. J Res Health Sci. 2013;13(1): 69-74.

Aalipour M, Mengli Zadeh N,Pourzamani H .Ethylbenzene Removal from Aqueous Solutions by Nano Magnetic Particles.Arch Hyg Sci . 2016;5(1):22-32.

Izadkhah B :Catalyst design for VOCs Catalytic Oxidation by modified Bi-Transition Metals Supported on HZSM-5 using Intelligent Systems, in chemistry. MSc thesis. tabriz university, chemistry Department;2010.

Tseng Ti, Lin Yi, Chen Yi, Chu H. A review of photocatalysts prepared by sol-gel method for VOCs removal. Int j mol sci.2010;11(6): 2336-61.

Garetto T, Vignatti CI, Borgna A, Monzón A. Deactivation and regeneration of Pt/Al 2 O 3 catalysts during the hydrodechlorination of carbon tetrachloride. Appl Cata B.2009; 87(3):211-19.

Zyoud A, Zu’bi A, Helal M,Park D,Campet G, Hilal H. Optimizing photo-mineralization of aqueous methyl orange by nano-ZnO catalyst under simulated natural conditions. J Environ Health Sci Eng.2015;13(1):46-56.

Niu F,Chen D,Qin L, Gao T, Zhang N, Wang S, et al. Synthesis of Pt/BiFeO 3 heterostructured photocatalysts for highly efficient visible-light photocatalytic performances. Sol Energy Mater Sol Cells. 2015;143(12): 386-96.

Choi J, Reddy D ,Islam M, Seo B, Joo S, Kim T. Green synthesis of the reduced graphene oxide–CuI quasi-shell–core nanocomposite: a highly efficient and stable solar-light-induced catalyst for organic dye degradation in water. Appl Surf Sci.2015; 358(12):159-167.

Jodaei A, Niaei A, and Salari D. Performance of nanostructure Fe-Ag-ZSM-5 catalysts for the catalytic oxidation of volatile organic compounds: Process optimization using response surface methodo-logy.Korean J Chem Eng. 2011;28(8):1665-71.

Tompkins D.Evaluation of photocatalytic air cleaning capability: a literature review and engineering analysis. ASHARE Research Project RP-1134, 2001.

Vignesh K, Suganthi A, Min B,Kang Mi.Photocatalytic activity of magnetically recoverable MnFe2O4/g-C3N4/TiO2 nanocomposite under simulated solar light irradiation. J Mol Catal A Chem.2014;395(12):373-83.

Cheng Z.-W, et al. Photocatalytic conversion of gaseous ethylbenzene on lanthanum-doped titanium dioxide nanotubes.J Hazard Mater.2013;254(6):354-63.

Shaheen W, Hong K. Thermal Characterization and Physico-Chemical Properties of Fe2O3− Mn2O3/Al2O3 Systems. J Therm Anal Calorim.2002;68(1): 289-06.

Howsawkeng Watts R.J,Teel A.Destruction of a carbon tetrachloride dense nonaqueous phase liquid by modified Fenton’s reagent. J Environ Eng.2005; 131(7): 1114-19.

Chu X, Zhang H.Catalytic decomposition of formaldehyde on nanometer manganese dioxide. Mod Appl Sci.2009; 3(4):177-82.

Ge H, Hu D, Li X, Tian Y, Chen Z, Zhu Y. Removal of low-concentration benzene in indoor air with plasma-MnO2 catalysis system.J Electrostat.2015;76(8):216-21.

Liping L, Jianguo Z, Lixian Y, Mingli F, Junliang W, Huang B. Room Temperature Catalytic Ozonation of Toluene over MnO2/Al 2 O 3.Chinese J Catal. 2011; 32(6): 904-16.

Mehrizadeh H, Niaei Al, Tseng H, Salari D, Khataee A.Synthesis of ZnFe2O4 nanoparticles for photocatalytic removal of toluene from gas phase in the annular reactor. J Photochem Photobiol A Chem.2017; 332(1):188-95.

Shaheen W.M, Hong K.S. Thermal characterization and physicochemical properties of Fe2O3–Mn2O3/Al2O3 system. Thermochim Acta. 2002;381(2): 153-64.

Abtahi M, Nadaffi K, Mesdaghinia A,Yaghmaian K, Nabizadeh R, Jafarzadeh N. Consolidated liquid bubble column bioreactor performance biofilter to remove dichloromethane from contaminated gas streams. Iranian J Health Environ.1393;7(4): 455-68.

Abedi K, Ghorbani-Shahna F,Jaleh B,Bahrami A,Yarahmadi R,Haddadi R,Gandomi M. Decomposition of chlorinated volatile organic compounds (CVOCs) using NTP coupled with TiO2/GAC, ZnO/GAC, and TiO2–ZnO/GAC in a plasma-assisted catalysis system. J Electrostat. 2015;73(2): 80-88.

Ghorbani Shahna F, Ebrahimi H, Jaleh B, Bahrami A.Decomposition of gas-phase chloroform using nanophotocatalyst downstream the novel non-thermal plasma reactor: by-products elimination. Int J Environ Sci Tech. 2015;12(11): 3489-98.

Suwannahong K, Liengcharernsit W, Sanongraj W, Kruenate J. Application of nano-TiO2/LDPE composite film on photocatalytic oxidation degradation of dichloromethane.J Environ Biol. 2012;33(2):955-99.

Abedi K,Ghorbani-Shahna F, Bahrami A, Jaleh B,Yarahmadi R. Effect of TiO2-ZnO/GAC on by-product distribution of CVOCs decomposition in a NTP-assisted catalysis system. Pol J Chem Technol.2015; 17(1): 32-40.

Hung W, Fu S,Tseng J,Chu H, Ko T. Study on photocatalytic degradation of gaseous dichloromethane using pure and iron ion-doped TiO2 prepared by the sol–gel method. Chemosphere. 2007;66(11): 2142-51.

Ebrahimi H,Ghorbani Shahna F, Bahrami A, Jaleh B. Photocatalytic degradation of volatile chlorinated organic compounds with ozone addition. Arch Environ Prot.2017;43(1): 65-72.

Abedi K,Ghorbani-Shahna F,Jaleh B,Bahrami A,Yarahmadi R. Enhanced performance of non-thermal plasma coupled with TiO2/GAC for decomposition of chlorinated organic compounds: influence of a hydrogen-rich substance. J Environ Health Sci Eng.2014;12(1): 119-32.

Logita H, Tadesse A, Kebede T. Synthesis, characterization and photocatalytic activity of MnO2/Al2O3/Fe2O3 nanocomposite for degradation of malachite green. African J Pure Appl Chem.2015;9(11): 211-22.

Tesfa O.F,Yaday A.T. Synthesis,Characterization and Photocatalytic Activity of MnO2/Al2O3/Fe2O3 Nanocomposite For Phenol Degradation. Chem Mater Res. 2014;6(10):73-86.

Cheng Z, Feng Li, Chen Ji,Yu Ji, Jiang Yi. Photocatalytic conversion of gaseous ethylbenzene on lanthanum-doped titanium dioxide nanotubes.J Hazard Mater.2013;254(6):354-33.

Yu J, Cai W, Chen Ji, Feng Li, Jiang Yi, Cheng Zh. Conversion characteristics and mechanism analysis of gaseous dichloromethane degraded by a VUV light in different reaction media. J Environ Sci.2012;24(10):1777-84.

Hong G, Ma C. Photocatalytic degradation of indoor air pollutants by Pt-TiO2. J Nanomater. 2012;2012(1):88-93.

Jiang L, Zhu R, Mao Y, Chen J, Zhang L. Conversion Characteristics and Production Evaluation of Styrene/o-Xylene Mixtures Removed by DBD Pretreatment. Int J Environ Res Public Health.2015;12(2):1334-50.

Dhada I, Sharma M, Nagar P.Quantification and human health risk assessment of by-products of photo catalytic oxidation of ethylbenzene, xylene and toluene in indoor air of analytical laboratories. J Hazard Mater.2016;316(10):1-10.




Iranian Journal of Health, Safety and Environment e-ISSN: :2345-5535 Iran university of Medical sciences, Tehran, Iran